User manual SONY TA-F511 schematic

[. . . ] 14 Notes on chip component replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing · Keep the temperature of soldering iron around 270°C during repairing. · Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). [. . . ] · Be careful not to apply force on the conductor when soldering or unsoldering. 4. Front Panel Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Chassis Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. --2-- SECTION 1 GENERAL This section is extracted from instruction manual. Rotate the semi-fixed resistors (RV501, RV601) for bias adjustment to the MIN side fully (counterclockwise direction). Turn ON the power button, and adjust RV501 and RV601 so that the digital voltmeter display becomes 22 mV ± 2mV within 5 seconds. After the adjustment, turn OFF the power button. Adjustment Location [MAIN BOARD] (Component side) Digital volt meter CN501 (TP) RV501 1 2 CN601 (TP) RV601 1 2 Digital volt meter C801 C802 Bias Adjustment SECTION 3 DIAGRAMS 3-1. CIRCUIT BOARDS LOCATION AC OUTLET board VOL board PHONO board PANEL board RM board AC SW board MAIN board TONE board HP board --3-- --4-- 3-6. IC BLOCK DIAGRAMS · Main section IC701 µPC1237HA 3-7. · CAPACITORS uF : µ F · COILS uH : µ H Ref. * Part No. Description Description Remark 1-666-040-11 AC OUTLET BOARD *************** < CONNECTOR > A-4392-944-A MAIN BOARD, COMPLETE ********************* < CAPACITOR > C501 C502 C503 C505 C506 C507 C508 C509 C510 C511 C512 C513 C514 C515 C516 C601 C602 C603 C605 C606 C607 C608 C609 C610 C611 C612 C613 C614 C615 C616 C701 C702 C703 C704 C705 C706 C707 C708 C709 C710 C711 C712 1-136-810-11 1-128-198-51 1-101-880-00 1-115-197-11 1-126-025-11 1-102-949-00 1-128-200-11 1-136-356-11 1-126-025-11 1-115-197-11 1-136-810-11 1-136-159-00 1-136-356-11 1-136-153-00 1-136-153-00 1-136-810-11 1-128-198-51 1-101-880-00 1-115-197-11 1-126-025-11 1-102-949-00 1-128-200-11 1-136-356-11 1-126-025-11 1-115-197-11 1-136-810-11 1-136-159-00 1-136-356-11 1-136-153-00 1-136-153-00 1-106-343-00 1-106-343-00 1-106-343-00 1-106-343-00 1-106-343-00 1-106-343-00 1-124-916-11 1-163-037-11 1-126-052-11 1-163-037-11 FILM ELECT CERAMIC ELECT ELECT CERAMIC ELECT FILM ELECT ELECT FILM FILM FILM FILM FILM FILM ELECT CERAMIC ELECT ELECT CERAMIC ELECT FILM ELECT ELECT FILM FILM FILM FILM FILM MYLAR MYLAR MYLAR MYLAR MYLAR MYLAR ELECT CERAMIC CHIP ELECT CERAMIC CHIP 220PF 22uF 47PF 100uF 330uF 12PF 47uF 470PF 330uF 100uF 220PF 0. 033uF 470PF 0. 01uF 0. 01uF 220PF 22uF 47PF 100uF 330uF 12PF 47uF 470PF 330uF 100uF 220PF 0. 033uF 470PF 0. 01uF 0. 01uF 1000PF 1000PF 1000PF 1000PF 1000PF 1000PF 22uF 0. 022uF 100uF 0. 022uF 4. 7uF 100uF 5% 20% 5% 20% 20% 5% 20% 5% 20% 20% 5% 5% 5% 5% 5% 5% 20% 5% 20% 20% 5% 20% 5% 20% 20% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 20% 10% 20% 10% 20% 20% 100V 63V 50V 25V 16V 50V 63V 100V 25V 25V 100V 50V 100V 50V 50V 100V 63V 50V 25V 16V 50V 63V 100V 25V 25V 100V 50V 100V 50V 50V 200V 200V 200V 200V 200V 200V 63V 25V 25V 25V 100V 25V * CN207 CN208 CN209 !CN210 1-564-321-21 1-580-230-11 1-564-321-00 1-251-597-11 PIN, CONNECTOR 2P PIN, CONNECTOR (PC BOARD) 2P PIN, CONNECTOR 2P OUTLET, AC (AC OUTLET) < FUSE > !F801 1-532-465-51 FUSE, TIME-LAG (3. 15A/250V) < FUSE HOLDER > FH805 FH806 1-533-183-11 HOLDER, FUSE 1-533-183-11 HOLDER, FUSE < TRANSFORMER > !T801 1-431-369-11 TRANSFORMER, POWER ************************************************************** * 1-663-769-11 AC SW BOARD *********** < CAPACITOR > !C810 1-113-920-11 CERAMIC < CONNECTOR > CN801 1-564-321-00 PIN, CONNECTOR 2P < SWITCH > !S801 1-762-581-11 SWITCH, AC POWER PUSH (1 KEY)(POWER) 0. 0022uF 20% 250V ************************************************************** * 1-663-768-11 HP BOARD ******** < CONNECTOR > CN307 1-691-766-11 PLUG (MICRO CONNECTOR) 4P < JACK > J301 1-778-870-11 JACK (PHONES) ************************************************************** 1-124-927-11 ELECT 1-126-052-11 ELECT -- 17 -- MAIN Ref. C713 C714 C715 C716 C717 C718 C719 C720 C721 C722 C801 C802 C803 C804 C805 C806 C807 C808 C809 C1001 C1002 C1003 C1004 Part No. Description 47uF 100uF 0. 1uF 0. 1uF 0. 1uF 0. 1uF 0. 1uF 0. 1uF 0. 1uF 0. 1uF 10000uF 10000uF 6200uF 6200uF 2. 2uF 0. 01uF 0. 01uF 1000uF 470uF 470PF 470PF 470PF 470PF 20% 20% 10% 10% 10% 10% 10% 10% 10% 10% 20% 20% 20% 20% 10% 5% 20% 20% 5% 5% 5% 5% Remark 50V 63V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 160V 400V 50V 25V 16V 50V 50V 50V 50V Ref. Description Remark 1-124-910-11 ELECT 1-126-365-51 ELECT 1-115-339-11 CERAMIC CHIP 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-117-394-12 1-117-394-12 1-117-395-11 1-117-395-11 1-136-880-11 1-161-744-00 1-136-153-00 1-126-690-51 1-126-103-11 1-102-824-00 1-102-824-00 1-102-824-00 1-102-824-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT FILM CERAMIC FILM ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC < CONNECTOR > CN201 CN202 CN203 * CN204 CN205 CN206 CN501 CN601 1-691-768-11 1-691-766-11 1-691-770-11 1-568-828-11 1-766-897-11 PLUG (MICRO CONNECTOR) 6P PLUG (MICRO CONNECTOR) 4P PLUG (MICRO CONNECTOR) 8P SOCKET, CONNECTOR 9P PIN, CONNECTOR (PC BOARD) 4P 8-719-200-82 DIODE 11ES2 8-719-200-82 DIODE 11ES2 < FUSE > ! [. . . ] Description Remark 1-124-910-11 ELECT 1-126-365-51 ELECT 1-115-339-11 CERAMIC CHIP 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-117-394-12 1-117-394-12 1-117-395-11 1-117-395-11 1-136-880-11 1-161-744-00 1-136-153-00 1-126-690-51 1-126-103-11 1-102-824-00 1-102-824-00 1-102-824-00 1-102-824-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT FILM CERAMIC FILM ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC < CONNECTOR > CN201 CN202 CN203 * CN204 CN205 CN206 CN501 CN601 1-691-768-11 1-691-766-11 1-691-770-11 1-568-828-11 1-766-897-11 PLUG (MICRO CONNECTOR) 6P PLUG (MICRO CONNECTOR) 4P PLUG (MICRO CONNECTOR) 8P SOCKET, CONNECTOR 9P PIN, CONNECTOR (PC BOARD) 4P 8-719-200-82 DIODE 11ES2 8-719-200-82 DIODE 11ES2 < FUSE > !R523 R524 R525 1-260-032-11 1-260-032-11 1-260-032-11 1-260-032-11 1-260-032-11 1-260-032-11 1-260-032-11 1-259-995-11 1-259-995-11 1-260-032-11 1-260-032-11 1-260-032-11 1-260-032-11 1-260-032-11 1-260-032-11 1-260-032-11 1-259-995-11 1-259-995-11 1-259-999-11 1-260-020-11 1-259-987-11 1-259-987-11 1-259-987-11 1-260-002-11 1-259-999-11 1-247-235-00 1-249-496-11 1-259-983-11 1-259-987-11 1-260-013-11 1-260-004-11 1-259-983-11 1-259-997-11 1-259-995-11 1-212-958-00 1-212-958-00 1-212-994-00 1-212-974-00 1-212-974-00 1-208-602-11 CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON CARBON CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF CARBON MELF FUSIBLE FUSIBLE FUSIBLE FUSIBLE FUSIBLE WIREWOUND 1M 1M 1M 1M 1M 1M 1M 1K 1K 1M 1M 1M 1M 1M 1M 1M 1K 1K 2. 2K 100K 220 220 220 3. 3K 2. 2K 620 100K 100 220 27K 4. 7K 100 1. 5K 1K 10 10 330 47 47 0. 22 0. 22 4. 7K 1. 5K 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 2% 5% 5% 2% 2% 2% 2% 2% 2% 2% 5% 5% 5% 5% 5% 10% 10% 2% 2% 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/3W 1/3W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/2W F 1/2W 1/2W 1/2W 1/2W 2W F F F F F 2W F 1/8W 1/8W 1/8W 1/2W 1/2W F 1/2W 1/8W 1/2W 1/10W 1/10W 1/2W 1/10W 1/10W 1/2W 1/10W 1/10W 1/2W 1/10W 1/10W 1/2W 1/10W 1/10W 1/2W 1/10W 1/10W 1/8W 1/8W 1/10W 1/10W 1-208-602-11 WIREWOUND 1-260-004-11 CARBON MELF 1-259-997-11 CARBON MELF 2W F 1/8W 1/8W -- 19 -- The components identified by mark !R803 R1001 R1002 R1003 R1004 R1005 R1006 PANEL Description METAL CHIP METAL GLAZE METAL GLAZE METAL GLAZE CARBON METAL GLAZE METAL GLAZE CARBON FUSIBLE FUSIBLE METAL GLAZE FUSIBLE METAL GLAZE METAL GLAZE METAL GLAZE 100K 15K 18K 4. 7K 820 10K 4. 7K 470 22 10 22K 2. 2 1K 1K 1K 1K 1K 1K 0. 5% 2% 2% 2% 5% 2% 2% 5% 5% 5% 2% 5% 2% 2% 2% 2% 2% 2% Remark 1/10W 1/10W 1/10W 1/10W 1/2W 1/10W 1/10W 1/2W 1/2W F 1/2W F 1/10W 1/2W F 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Q901 Q902 Q903 Q904 8-729-424-08 8-729-424-08 8-729-424-08 8-729-424-08 Ref. Description Remark 8-719-313-50 DIODE SEL6810A-TH12 (TAPE) 8-719-313-50 8-719-400-20 8-719-801-78 8-719-801-78 8-719-801-78 DIODE DIODE DIODE DIODE DIODE SEL6810A-TH12 (MD) MA152WA 1SS184 1SS184 1SS184 Part No. [. . . ]